5 Common Problems with Prime Time Crusader (Solution Added)

The Prime Time Crusader is a new 21st-century icon, setting a new benchmark in fifth wheels. It comes with updated water line fittings that are covered by a 25-year guarantee.

A smoke alarm, propane alarm, fire extinguisher, and a one-year emergency roadside assistance package are included as safety features.

But, the RV has a few drawbacks that I would like to address.

Some of the most prevalent difficulties are awning and pipe leaking, water heater not working, faulty door, battery losing power, and AC malfunctioning.

I’ll tell you about the causes, symptoms, and solutions to these issues. So keep reading to find out more about the Prime Time Crusader issues and concerns.

Problems and Solutions at a Glance:

Problems with Prime Time Crusader	Solutions
Awning and Pipe Leakage	Reset the system and clean the air filter
Water Not Heating Up	Adjust the thermostat or replace the heater
Faulty Door	Apply sealant to prevent warping
Battery Losing Power	Unplug when it is not in use
Problem with the AC Unit	Examine the pipe regularly and replace it if needed

Table of Contents

5 Common Problems with Prime Time Crusader and Their Solutions

Some of the issues and the possible solution for this RV are stated below:

1. Awning and Pipe Leakage

Water leaking is the most common issue with Prime Time Crusader RVs.

The shower drain pan became dislodged from the drainpipe, resulting in sudden awning flooding. Since the pipes aren’t attached properly, water might leak from the ceiling as well.

If the water remains on your floor for an extended period, it might cause damage. The cost of repairing or replacing the floor will be substantial.

The Fix:

Pipes should be examined regularly. If you see any cracking or misalignment, try to correct it as quickly as possible.

Repair or replace the pipe immediately, because the longer you wait, the more damage you will incur.

It’s preferable if you consult a professional about this because it’s a complicated situation. If you decide to fix this yourself, make sure to switch off all the water lines while you’re working.

2. Water Not Heating Up

The water heater in this RV is an electric water heater with a capacity of at least 6 gallons of water at a time. The heater may not be providing hot water due to a blown fuse or tripped circuit breaker.

The thermostat is primarily to blame in this circumstance. This issue can be caused by a thermostat if that has been misadjusted.

Reduced water flow, stinky or discolored water, insufficient hot water, and hearing some alarming noises from the heater are all symptoms that there is a problem with the water heater.

The Fix:

The thermostat should be thoroughly examined. The thermostat must be properly adjusted, as this is the primary cause.

If there are any loose plumbing connections, tighten them to stop the leak, but don’t over-tighten them. To get rid of the odor, clean the heater thoroughly. In this circumstance, it would be better if you seek professional advice.

If the problem persists, you can replace the heater. For an RV, a standard water heater with a capacity of 10 gallons of water is sufficient. This can cost somewhere from $800 to $1,000.

3. Faulty Door

The Crusader doors are known for being difficult to open. The doors do not close completely for a variety of causes, including loose screws, and an unleveled trailer. A defective latch can also cause this issue

The crusader’s door warping was a major source of consumer dissatisfaction. Moisture that penetrates the door might cause it to deform over time.

This results in a jammed door, dragging on the floor, and making it difficult to operate.

The door might be damaged by high heat or dampness. A moisture imbalance between the exterior and interior of the RV might cause wood doors to expand if there is too much heat or moisture.

The Fix:

It is preferable to hire a professional locksmith rather than attempting to solve the door latching problem yourself.

You may use sealant on all sides of the door to prevent it from warping. The wood will be completely protected against the weather if the sealer is applied appropriately.

To keep the moisture level in the RV under control, a dehumidifier would be a smart choice.

4. Battery Losing Power

Many people suffer from battery power issues with their Prime Time Crusader. After using the RV for 3 to 4 years, the lifetime of the battery reduces. As a result, you will get less power from it.

The lack of battery power might cause harm to your RV’s equipment. The battery’s lifespan will be diminished if the battery is used carelessly.

The Fix:

The first step in preventing your batteries from dying is to take care of them. Remember to unhook the cord and recharge the battery when you take a long break.

Use the battery with caution. Check the water level regularly. It is preferable to replace the battery if it becomes old and no longer supports your RV. Contacting your dealer is the best solution for any problem.

5. Problem with the AC Unit

The circuit breaker might be the problem if your air conditioner isn’t working. Frequently, the breaker has been tripped, preventing your air conditioner from working.

The air conditioner works perfectly in automatic mode. If the air conditioner turns on and off repeatedly, a thermostat issue might be the cause.

A faulty thermostat might prevent the cooling system from receiving a signal. The thermostat might be out of calibration, or the problem could be frayed wire.

Due to prolonged usage, the air filter may get old and clogged, limiting the volume of air exiting and entering the air conditioner.

The Fix:

First and foremost, locate the circuit board and reset the system. Attempt to locate the operating manual, which will provide you with information on the model and how to resolve the issue.

Thoroughly inspect, then repair, or replace the thermostat.

The air filter must be cleaned regularly. Your air conditioner may be damaged by a dirty air filter. If the filter becomes too old, it is recommended that you should change it.

If you are not an expert at repairing electrical problems or are not comfortable climbing up onto the roof of the RV, you should hire a professional. It will also be secure, ensuring that the crisis does not worsen.

What Majority of the Users Feel?

Due to its significant expense, the Prime Time Crusader is difficult to purchase. The RV is one of the most elegant ones in the RV business. But many users are upset with some of the flaws.

In RV Insider, the average rating for the RV is 3.2, which is fairly respectable.

The water heater failing to heat up water is a common complaint with many of the Prime Time Crusader users.

Final Thoughts

I’ve already highlighted the Prime Time Crusader’s minor and resolvable issues. Despite these flaws, this RV is a fantastic purchase.

The Prime Time Crusader is well-known for its outstanding characteristic. If you’re considering purchasing this crusader, keep in mind the flaws I have mentioned.

Maintaining your RV in excellent operating order will also help to lessen the frequency of these issues.

Related Posts:

[su_list icon=”icon: mail-forward” icon_color=”#07cd56″]

[/su_list]

5 Common Problems with Prime Time Crusader (Solution Added)